1-20 ton gas/oil fired boiler
Capacity: 1-20 ton/h
Pressure: 0.7-2 Mpa
Fuel: Nature gas, coke oven gas, biogas, methanol, liquid propane gas, diesel, heavy oil, light oil, crude oil, etc.
Industries: Heat supplying, chemical, food, textile, printing and dyeing, cigarettes and tobacco, fodder, pharmacy, building materials, brewery, rubber, hospital etc.
7-70 MW gas/oil fired hot water boiler
Capacity: 7-70 MW
Pressure: 1.0-1.6 Mpa
Fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, LPG, diesel, heavy oil, light oil, crude oil, etc.
Industries: Heat supplying, hospital, colleges and universities.
2.8-29mw coal fired boiler
Capacity: 2.8-29mw
Pressure: 1.0-1.25 Mpa
Fuel: Bituminous coal, lean coal, anthracite
Industries: Heating, hotels, schools, hospitals
horizontal thermal fluid heater
Capacity: 700 - 14000 kw
Pressure: 0.8 - 1.0 Mpa
Fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil
Industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries
1-20 ton biomass fired boiler
Capacity: 1-20 ton/h
Pressure: 0.7-2.5 Mpa
Fuel: Biomass particles
Industries: Heating, chemical, food, tobacco, textile, printing and dyeing, feed, medicine, building material, wine, rubber, hospital

Use of a Waste Heat Boiler to Capture Energy from Flammable
From Flammable Noncondensable Gas at Geothermal Power Plants Noncondensable gas, NCG, H2S abatement, burn/scrub, waste heat boiler , WHB , waste heat recovery , sulfuric acid, contacted to gain purchased equipment costs .

Process and Plant Design for 99% Sulfur Recovery - Energy 2030
All reheat units utilize the steam produced in the waste heat boiler . receives the tail gas coming from the Claus plant at an H2S to SO2 ratio of estimated based on delivered purchased equipment cost using the factored estimate method.

"Double Claus Plant Capacity," Oil & Gas Journal, Sept. 27, 1993, pp
sulfur plants by using oxygen in- stead of air has waste - heat boiler duty is much less, as compared to This price , how- ever, fairly represents the cost of H2S in air to produce S02 intro- duces too . costs in the form of purchased oxygen.

Claus Waste Heat Boiler Economics - Optimized Gas Treating
In this paper, the economics of several Claus Waste Heat Boiler (WHB) of sulfidic corrosion and the resulting impact on boiler tube life and sulfur plant reliability economics are .. H2S present correlate directly into the sulfidic corrosion rate[2]. replacement cost was estimated to be a new exchanger purchase in the

An H2S Thermal Cracking Claus Furnace Modification For the
Abstract Direct thermal splitting of H 2 S into H 2 and S within a separate ceramic heat exchange chamber, using only heat generated by combustion of the

Waste heat recovery - Alfa Laval
waste heat recovery is to try to recover maximum amounts of heat in the their associated life cycle costs ( purchase , maintenance, etc). Different heat, the whole energy system of the plant must be analyzed, .. Reduced CO2 emissions.

Waste Heat Recovery Technology Assessment - Department of Energy
13 Feb 2015 Challenges and Barriers for Waste Heat Recovery . . estimate major areas of energy use in a plant as well as losses from the subsystems .. Identify cost , design, and engineering performance requirements needed for TEGs to assuming that 5% of the market buys TEGs per year. .. and SO2 ) or liquids.

Claus Process - an overview | ScienceDirect Topics
The Claus plant furnace is often used for disposal of unwanted plant wastes process is the most common, due to its simplicity and lower costs . The CO2 stream can be sold as a product for enhanced oil recovery . Exercising the Option of CO2 Slippage to Mitigate Acid Gas Flaring During SRU Expansion Bellow Failure.

process - Haldor Topsoe
leaving the waste heat boiler will have a temperature of approximately 400 C. The gas then Figure 1. Process flow diagram for WSA plant treating H2S gas.

Introduction to the Sweetening of Natural Gas with Emphasis on
Sweetening is done to remove hydrogen sulfide gas and then the famous Claus 1.2 Processing Natural Gas A Natural Gas Processing Plant Natural gas, as it is .. 2.3 Waste Heat Boiler (B-100) A WHR boiler is a closed vessel in which water 1218 The present cost purchased of the equipment is calculated as follows:

Energy Efficiency and Cost Saving Opportunities for - Energy Star
Energy waste is found in all plants , and improving energy efficiency goes right to the . Insulate reformer furnace Recover heat from solvent regeneration in CO2 . Data on energy use can be found in utility bills, fuel purchase receipts, and

Sulfur Process Technology(PDF 2.0 MB) - Linde Engineering
The basic Claus Process mixed hydrogen sulfide with oxygen and passed particularly true for those plants equipped with waste heat boilers on the incin- erator. .. 80% or more of the cost of the upstream Claus plant ), but expensive to oper-.

Steam boilers and waste heat boilers
plants . In order to design boiler house concepts appropriate for the task in hand, with characteristics that allow cost effective and futureproof steam generation. Anyone searching for a new steam boiler or waste heat boiler for the Clarification, purchase , delivery and . imported and, as a renewable and CO2 neutral.

Industrial Fuel Gas Demonstration Project, Memphis: Environmental - Google Books Result

Introduction to Wet Sulfuric Acid Plants Optimization - UPCommons
Moreover, the plant has two heat - recovery boilers that produce steam at. 40 bar and 5 .. 6.6 Decision variables and purchase costs of the first and second heat exchanger .. on the sulfur source (elemental sulfur, waste acid, SO2 , H2S , etc.)

Hydrogen Sulfide Combustion: Relevant Issues under Claus
Hydrogen Sulfide Combustion: Relevant Issues under Claus Furnace Conditions which also is an important issue in sulfur plant design and associated tail gas units. .. Design of SRU Thermal Reactor and Waste Heat Boiler Considering

Cogeneration & Trigeneration How to Produce Energy - Giz
CO2 . Carbon dioxide. Cogen. Cogeneration (Combined heat and power production) . through displacement of higher- cost generation plants , increased use of CHP . Waste heat recovery and thus cogeneration can be operated in all types of amount of electricity produced (which does not have to be purchased from.

Novel Coal Gasification Process: Improvement - [email protected]
to purify the H2S stream to be sent to the thermal furnace from the syngas and CO2 , in order to reduce the reactor inlet flow rate. Therefore, acid gases represent a dangerous and costly waste . At H2S industrial plant simulation software: Aspen Hysys. . In the syngas stream to be sold , there is not H2S . The other